Product ID:RECYCLED LATEX PAINT
MSDS Date:04/18/1994
FSC:8010
NIIN:01-380-2381
MSDS Number: BWFSD

E-COAT RECYCLED PAINT PRODUCTS

5101 RALEY BLVD
SACRAMENTO, CA 95838
US

Emergency Phone: 916-921-0165

Info Phone: 916-921-0165

Preparer: RAY JULIAN

Cage: TO169

E-COAT RECYCLED PAINT PRODUCTS

SACRAMENTO, CA 95838 US

Telephone: 916-921-0165

Cage: TO169

ETHYLENE GLYCOL (SARA III)

CAS: 107-21-1

RTECS: KW2975000

Fraction By Weight: 1-3%

OSHA PEL 50 PPM

ACGIH TLV: 50 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

SILICA, CRYSTALLINE

CAS: 14464-46-1

RTECS: VV7325000

Fraction By Weight: 10-20%

ACGIH TLV: 0.05 MG/M3

LESS THAN 250 G/L

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:PROLONGED/REPEATED OVEREXPOSURE TO
HIGH CONCENTRATIONS OF RESPIRABLE (AIRBORNE) CRYSTALLINE SILICA
DUSTS (GENERATED BY SANDING/GRINDING DRIED PAINT/OTHER BUILDING
MATERIALS W/O WEARING PROPER RESPRTRY PROTECTION) CAN CAUSE
SILICOSIS, NON-CANCEROUS LUNG DISEASE-CAN RESULT IN SUBSTANTIAL
IMPAIRMENT OF BREATHING FUNCTION
Effects of Overexposure:DIZZINESS, HEADACHE, NAUSEA, CONFUSION,
IRRITATION TO UPPER RESPIRATORY TRACT, SKIN & EYE IRRITATION.
Medical Cond Aggravated by Exposure:SEE YOUR PHYSICIAN FOR SPECIFIC
MEDICAL OPINION REGARDING YOUR CONDITION.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT
PHYSICIAN. EYE: FLUSH WITH LARGE VOLUMES OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. SKIN CONTACT: WIPE OFF WITH A RAG. WASH
THOROUGHLY WITH SOAP AND WATER. INGESTION: CONSULTHOSPITAL
EMERGENCY ROOM OR POISON CONTROL CENTER IMMEDIATELY.

Flash Point:>200F,>93C
Extinguishing Media:N/R * 8.5
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF STEAM PRESSURE) WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:VENTILATE AREA TO PREVENT BUILD-UP OF VAPORS.
FOR SMALL SPILLS, SOAK UP WITH ABSORBENT. FOR LARGE SPILLS, DIKE
AREA WITH ABSORBENT MATERIAL AND SCOOP UP LIQUIDS.

Handling and Storage Precautions:STORE UPRIGHT IN SEALED CONTAINERS
AWAY FROM HEAT AND FLAME.
Other Precautions:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.

Respiratory Protection:USE PARTICLE MASK (NIOSH/MSHA TC-21C) TO AVOID
BREATHING SPRAY MIST/SANDING DUST. LOCAL VENT ADEQUATE TO KEEP
VAPOR CONCENTRATIONS W/IN ACCEPTABLE (TLV) LIMITS. IF LOCAL VENT
NOT SUFFICIENT OR WHERE L EL EXCEEDED WEAR FITTED TC-23C OR BETTER
Ventilation:LOCAL CROSS VENT OR MECHANICAL EXHAUST SUFFICIENT TO KEEP
ALL HAZARDOUS VAPOR CONCENTRATIONS BELOW PRESCRIBED LIMITS.
Protective Gloves:RECOMMEN IF NEEDED-PREVENT EXTEND EXPOSR
Eye Protection:GLASSES WITH SIDE SHIELDS OR GOGGLES
Supplemental Safety and Health
CONTAINS PIGMENTS SUCH AS MINERAL SILLICATES,SILICON DIOXIDE & TITANIUM
DIOXIDE.NOT HAZARDOUS IN WET PAINT,BUT MAY REACH HAZARDOUS LEVELS
IN DUST FROM SANDING/GRINDING DRIED PAINT.LIKE MOST NATURAL OC
CURING MINERALS,PIGMENTS CONTAIN SOME CRYSTALLINE SILICA-IARC
DETERMINED LIMITED EVIDENCE FOR CARCINOGENICITY IN HUMANS.

Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Vapor Density:< AIR
Spec Gravity:1.25-1.35 H20=1
pH:7.5- *
Viscosity:80-100 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:VARIOUS COLORS
Percent Volatiles by Volume:60-70

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING.

Waste Disposal Methods:DISCARD IN LANDFILL IN SEALED METAL CONTAINERS
AWAY FROM HEAT AND FLAME AND IN ACCORDANCE WITH LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.